Смяна на крушки на таблото и ремонт тид дисплей Опел Зафира А
roro 05 октомври 2010 - 21:00
Днес имах малко свободно време в офиса и както винаги се зарових в опел форумите. Имам намерение да си ремонтирам сам тид дисплея (тъй като ми липсва някой и друг пиксел), и въпреки че има материали със снимки и в нашия форум, реших че това ще е интересно за всички съфорумници.
Ако модераторите решат, че не си заслужава - да я изтрият. Нямам време да поствам снимките във форума, и затова давам директно линкове към снимковия материал. Не знам до кога ще са активни тези линкове.
1. Демонтаж на таблото на Опел Зафира - колата е с дясна дирекция и снимките са малко разхвърляни, но ще се ориентирате.
Replace the odometer bulb on a 2001 Zafira:
01.JPG (112,22K)
Брой изтегляния: 138 There are 4 faux mounting screws around the radio that need to be removed with a hex driver. These cover the holes used for removal tool.
02.JPG (116,52K)
Брой изтегляния: 103 The ashtray and lighter unit needs to prised/popped downwards once the bottom screw is removed.
03.JPG (61,74K)
Брой изтегляния: 84 Once the ash tray is removed there are two screws to removed below the fan controls
04.JPG (88,3K)
Брой изтегляния: 76 As per the ashtray unit, the fan control unit needs to pop downwards
05.JPG (108,8K)
Брой изтегляния: 62 You will need to bent wire to pull the radio (through the CD slot) and some sharpen wire to depress the locking clips through the mounting holes.
06.JPG (92,94K)
Брой изтегляния: 55 Push the removal tools in and pull the radio with the fashioned puller you have made.
07.JPG (78,44K)
Брой изтегляния: 61 You see here once the radio is removed how the pushes the retain clips in.
08.JPG (53,15K)
Брой изтегляния: 66 You need a Torx T12 driver to remove most of the screws. You can start below the ashtray with this one.
09.JPG (66,6K)
Брой изтегляния: 61 You will find 3 screws to removed above the main dash
10.JPG (101,24K)
Брой изтегляния: 55 This screw was tricky to find. You need to prise out the vent grille and you will find a screw to remove
11.JPG (59,03K)
Брой изтегляния: 60 Gently prise the fan unit out
12.JPG (88,61K)
Брой изтегляния: 53 The DIN cage for the radio needs to be removed. There is a single Torx screw in the back.
13.JPG (80,5K)
Брой изтегляния: 58 Once you have the screw out, the cage is removed pulling in the side a bit. As you have the dash loosened, this is probably most easily done from the back.
14.JPG (74,52K)
Брой изтегляния: 50 Remove the antenna connector and other power connects. They are just clipped in.
15.JPG (57,52K)
Брой изтегляния: 52 The steering wheel height adjustment lever handle needs to be removed.
16.JPG (99,21K)
Брой изтегляния: 45 The cover around the steering wheel stalks have two screws on the side, and one screw underneath that have to be removed
17.JPG (80,7K)
Брой изтегляния: 49 This is the screw underneath the cover.
18.JPG (79,84K)
Брой изтегляния: 52 Once you have removed the top cover, there are two other screws to be removed for the bottom cover.
19.JPG (43,41K)
Брой изтегляния: 59 The stalk switches are easily removed by depressing the clips.
20.JPG (71,88K)
Брой изтегляния: 63 The light switch unit pops out.
21.JPG (61,45K)
Брой изтегляния: 63 The light switch unit sockets slides down and out.
22.JPG (64,4K)
Брой изтегляния: 61 Remove the clock by sliding it down
23.JPG (53,68K)
Брой изтегляния: 60 The clock just slides out.
24.JPG (38,07K)
Брой изтегляния: 53 The dash does come out, but you will need to push down quite firmly to get it past the surround
25.JPG (81,85K)
Брой изтегляния: 65 All that's left after instrument panel is out.
26.JPG (70,24K)
Брой изтегляния: 73 The new bulb on the left and the blown one on the right.
27.JPG (83,53K)
Брой изтегляния: 60 The receptacle on the back of the instrument panel where the bulbs are.
28.JPG (94,33K)
Брой изтегляния: 73 Now just to put it back together!
29.JPG (54,39K)
Брой изтегляния: 52 Only two screws left over
30.JPG (70,89K)
Брой изтегляния: 57 Wow, look mum, it works!
2. Ремонт на ТИД дисплей
http://members.home....20reparatie.htm
Това е колеги, като си разглобявам таблото другата седмица, ще направя и аз снимки.
ЗАБЕЛЕЖКА КЪМ ПРАВЕЩИТЕ ФОРУМА - Имам проблем при постване с Мозила. С Интернет експлорер нямам проблем. Не е само от този компютър.
Мнението беше редактирано от dvasilev: 25 ноември 2017 - 00:32
Причина за редактиране:: Качвам снимките директно в темата за да не се загубят :)
Ако модераторите решат, че не си заслужава - да я изтрият. Нямам време да поствам снимките във форума, и затова давам директно линкове към снимковия материал. Не знам до кога ще са активни тези линкове.
1. Демонтаж на таблото на Опел Зафира - колата е с дясна дирекция и снимките са малко разхвърляни, но ще се ориентирате.
Replace the odometer bulb on a 2001 Zafira:
01.JPG (112,22K)
Брой изтегляния: 138 There are 4 faux mounting screws around the radio that need to be removed with a hex driver. These cover the holes used for removal tool.
02.JPG (116,52K)
Брой изтегляния: 103 The ashtray and lighter unit needs to prised/popped downwards once the bottom screw is removed.
03.JPG (61,74K)
Брой изтегляния: 84 Once the ash tray is removed there are two screws to removed below the fan controls
04.JPG (88,3K)
Брой изтегляния: 76 As per the ashtray unit, the fan control unit needs to pop downwards
05.JPG (108,8K)
Брой изтегляния: 62 You will need to bent wire to pull the radio (through the CD slot) and some sharpen wire to depress the locking clips through the mounting holes.
06.JPG (92,94K)
Брой изтегляния: 55 Push the removal tools in and pull the radio with the fashioned puller you have made.
07.JPG (78,44K)
Брой изтегляния: 61 You see here once the radio is removed how the pushes the retain clips in.
08.JPG (53,15K)
Брой изтегляния: 66 You need a Torx T12 driver to remove most of the screws. You can start below the ashtray with this one.
09.JPG (66,6K)
Брой изтегляния: 61 You will find 3 screws to removed above the main dash
10.JPG (101,24K)
Брой изтегляния: 55 This screw was tricky to find. You need to prise out the vent grille and you will find a screw to remove
11.JPG (59,03K)
Брой изтегляния: 60 Gently prise the fan unit out
12.JPG (88,61K)
Брой изтегляния: 53 The DIN cage for the radio needs to be removed. There is a single Torx screw in the back.
13.JPG (80,5K)
Брой изтегляния: 58 Once you have the screw out, the cage is removed pulling in the side a bit. As you have the dash loosened, this is probably most easily done from the back.
14.JPG (74,52K)
Брой изтегляния: 50 Remove the antenna connector and other power connects. They are just clipped in.
15.JPG (57,52K)
Брой изтегляния: 52 The steering wheel height adjustment lever handle needs to be removed.
16.JPG (99,21K)
Брой изтегляния: 45 The cover around the steering wheel stalks have two screws on the side, and one screw underneath that have to be removed
17.JPG (80,7K)
Брой изтегляния: 49 This is the screw underneath the cover.
18.JPG (79,84K)
Брой изтегляния: 52 Once you have removed the top cover, there are two other screws to be removed for the bottom cover.
19.JPG (43,41K)
Брой изтегляния: 59 The stalk switches are easily removed by depressing the clips.
20.JPG (71,88K)
Брой изтегляния: 63 The light switch unit pops out.
21.JPG (61,45K)
Брой изтегляния: 63 The light switch unit sockets slides down and out.
22.JPG (64,4K)
Брой изтегляния: 61 Remove the clock by sliding it down
23.JPG (53,68K)
Брой изтегляния: 60 The clock just slides out.
24.JPG (38,07K)
Брой изтегляния: 53 The dash does come out, but you will need to push down quite firmly to get it past the surround
25.JPG (81,85K)
Брой изтегляния: 65 All that's left after instrument panel is out.
26.JPG (70,24K)
Брой изтегляния: 73 The new bulb on the left and the blown one on the right.
27.JPG (83,53K)
Брой изтегляния: 60 The receptacle on the back of the instrument panel where the bulbs are.
28.JPG (94,33K)
Брой изтегляния: 73 Now just to put it back together!
29.JPG (54,39K)
Брой изтегляния: 52 Only two screws left over
30.JPG (70,89K)
Брой изтегляния: 57 Wow, look mum, it works!
2. Ремонт на ТИД дисплей
http://members.home....20reparatie.htm
Това е колеги, като си разглобявам таблото другата седмица, ще направя и аз снимки.
ЗАБЕЛЕЖКА КЪМ ПРАВЕЩИТЕ ФОРУМА - Имам проблем при постване с Мозила. С Интернет експлорер нямам проблем. Не е само от този компютър.
Мнението беше редактирано от dvasilev: 25 ноември 2017 - 00:32
Причина за редактиране:: Качвам снимките директно в темата за да не се загубят :)
deforse 06 октомври 2010 - 07:51
Темата е 6-ца. Нека само да се постарае някой ( админите или модовете , )да качи тия снимки на сървъра на форума, че да не се губят. Иначе е приблизително същото като на астрата (Ф). При мен само дето не се разглобява всичко, а се сваля само самото табло.
Поздрави
Поздрави
roro 09 октомври 2010 - 16:56
Така. Реших да си ремонтирам ТИД дисплея на Зафирата. Разглобих таблото за около половин час, свалих дисплея и от там се започнаха мойте одисеи. Въпреки че съм инжинер и съм добър в разни пипкави работи, тези дисплеи нямат отремонтиране. Не знам как някой е успял да си го отремонтира. При мен лентовият кабел е с графитни писти, а не медни. Както да се мъчи човек да зачисти, или да отлепи леко кабела, графитните писти директно се олюпват. Развалянето на тези дисплеи е чиста конструктивна недомислица. Разчитат кабела да прави контакт, с подложка от един ластик.Платката не е захваната никъде с винтове и от сътресения и вадене на куплунга платката леко се усуква и някоя графитна писта дава фира(не мога да повярвам че го е правил немец). След тоталния неуспех отидох до една морга и след уговорка че ще го тествам и ако нестава ще го върна(срещу цена 80 лв.) с тръпнещо сърце се прибрах в гаража където ме чакаше разглобена Зафирката. Закачих дисплея и ООООО Чудоооо Работеше перфектно, без нито един липсващ пиксел. Та така завърши моята одисея - все пак с щастлив край.
Успех на всички които се заемат с това. А сега наближава ракиено време и с кеф ще пийна едно и за съфорумниците
Успех на всички които се заемат с това. А сега наближава ракиено време и с кеф ще пийна едно и за съфорумниците
How to 15 юни 2019 - 11:55
Здравейте някои знае ли от къде може да се купят крушки за дисплея на астра 1.4